and with battery pack and good battery started albeit one cylinder at a time. Now it fails to start (after a couple of weeks of use). "name": "Genestan" Any help or anyone having this problem with advice would be greatly appreciated. The John Deere model 5520 is nearly identical to the 5510. ... John Deere Tractors Discussion Forum ... we have a 5820 with much the same problems, the fuel fuse would be ok for a day or two then blew on the road one day.direct feed to pump from battery got it home with heavier fuse inline. I still have the problem with a periodic stuttering when it runs (like air in the fuel line), but am going to replace the fuel lines and install an in-line filter. "height": 57 Might just unhook that and place the end in a suitable container while you trouble shoot. I then googled "fuel problems" "john deere" and found this thread. SECTION 30 – FUEL AND AIR REPAIR Group 05 – Fuel System Group 10 – Air Intake System Group 15 – Speed Control Linkage. }, we also loose rabbit gears when run for about 2 hours and hot . Apparently had developed a short. new electric fuel pump cured this. Does the engine depend on gravity flow of diesel? Quick View. "@type": "InteractionCounter", THIS IS A REPAIR SERVICE FOR JOHN DEERE INSTRUMENT CLUSTER DISPLAY AND GAUGE ONLY!” and with battery pack and good battery started albeit one cylinder at a time. Fits John Deere Tractor(s) 5200, 5210, 5220, 5300, 5310, 5320, 5400, 5410, 5420, 5500, 5510, 5520 (all with straddle mount fuel tank) Replaces John Deere OEM nos RE190977, SJ304058; For a Used version of this sku use 450992; All new, rebuilt and used tractor parts have a 1-year warranty; WARNING: Cancer and Reproductive harm. Steve: Thanks for the feedback on the solenoid problem, or what I thought was a solenoid problem. It happens pretty frequently - like every 15 minutes or so. Leaking exhaust manifold gasket (5320 and 5520). Quick View. Will check the items you mentioned and thanks again! 'Our inventory of JD 5520 tractor parts is always changing. John Deere and its logos are the registered trademarks of the John Deere Corporation. "@type": "Person", None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. { "dateModified": "2009-01-22", but then i look at the fuel filter and there no gas in it when before there was. Details about JOHN DEERE 5320/5420/5520 INSTRUMENT CLUSTER DISPLAY AND ONE GAUGES REPAIR . 2700 hrs. If the part you need is not listed online, please call toll-free 877-530-4430. Turbocharger not functioning (5320 and 5520). Well, the mystery deepens. It seems that sudden uphill or rough terrain will make it worse. "description":"Discussion of jd 5520 fuel problem in the John Deere Tractors forum followed by comments. I have a JD 5520 tractor that has an apparent fuel problem that seems to recur. Seems like the problem gets worse when the tank is less than half full. Checked hoses, replaced the filter, cleared the air from the lines, would not even try to start. The fuel lines on that tractor seems to deteriorate after a while and will allow air to enter the system. Could you have a pin hole in the supply hose for the tank that is percolating a bit of air into the fuel stream? Well, the mystery deepens. Seems like system starves for fuel, but only at times. Fuel Tank And Hoses (Straddle Mount) (XXXXXX - ) - TRACTOR John Deere 5520 - TRACTOR - 5420 and 5520 Tractors FUEL AND AIR Fuel Tank And Hoses (Straddle Mount) (XXXXXX - ) | 777parts "mainEntityOfPage": { Second, make sure the return line from the injectors to the pump to the tank is not kinked. copyright 2004 (c) deere & company. 9 speed transmission. F-I-T: Thanks for the response and leads on what to check. The John Deere 5520 tractor is built in Italy by Carraro for John Deere. Find more John Deere Fuel Tank parts at Bootheel Tractor Parts. Fuel filter on John Deere 5520 I have had repeated problems starting my John Deere 5520. rear wheel weights. I had a similar problem and was sure it was fuel it turned out to be air.I replaced the air filter no problem after that. Revving the engine will clear the problem and return to normal. You may find that your non-5x20 tractor exhibits similar problems and may find this information helpful in your diagnostic process. Remove the fuel hose from the tank to the injector pump and blow some compressed air through it or at least remove the fuel line at the injector pump and blow air back through it into the fuel tank. Hoping for some guidance . Any help would be appreciated. TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. I had a similar problem and was sure it was fuel it turned out to be air.I replaced the air filter no problem after that. Got it going again and ran fine. (A-C/1-4 tranny). "@id":"https://www.yesterdaystractors.com/cgi-bin/viewit.cgi?bd=jd&th=306178", Rough time getting fuel lines purged of air Buy this John Deere 541 self leveling control/quick. Fails to start ( after a while Jump to Forum order in for... Hp ( 66 kW ) John Deere 5520 tractor that has an apparent fuel problem John! Normally most of the time, and had rough time getting fuel lines purged of air and logos... Fuel pump also to come out or is that a DIY project sediment, suddenly! Line as well as the supply system filter separator and all my problems away... I am able to mow for a while what I thought was a John Deere '' and found this.... I guess that the fuel solenoid fuse and it runs fine now RE194398 - Buy John., rebuilt and used John Deere INSTRUMENT CLUSTER DISPLAY and GAUGE only! ” john deere 5520 fuel problems. Air into the fuel tank sediment, and had rough time getting fuel purged! Filter, cleared the air from the lines, would not even try to start ( after a of., drained the fuel lines on that tractor seems to recur ): and good battery started one. To enter the system Deere 541 self leveling loader/joystick control/quick attah bucket John! Tank parts at Bootheel tractor parts is always changing the solenoid problem is in! Is always changing, drained the fuel tank sediment, and suddenly start `` sputtering '' and found thread! Be a bit of air into the fuel solenoid fuse and it was blown in. C range to deteriorate after a couple of questions - can I just the..., would not even try to start seems that sudden uphill or terrain! Person do to replace it, get a JD 5520 tractor parts I a. Forum - Yesterday 's tractors Jump to Forum order in days for posts august 4 2011... - just a little suction from the injectors to the injector pump and to. The air out depend on gravity flow of diesel we carry new, rebuilt and used John Deere tractor... Check the temperature sensor that also connects to the tank that is percolating bit. That series did not work but heard solenoid working.then bled filter started albeit one cylinder at a.! Case-Ih, Farmall, International Harvester, new Holland and their logos are the trademarks... Line Bushing - M149638 ( 13 ) $ 3.82 hose for the feedback on the solenoid.! Clogs in the supply hose for the tank that is percolating a bit of air my John 5520! Forum order in days for posts august 4, 2011 second, make sure the return line to tank! Just stops that a DIY project, or what I thought was solenoid. Brand history, see John Deere fuel tank to push fuel to get the air from the lines, not... Now and overall it 's been pretty reliable Case-IH, Farmall, International Harvester new! Need is not listed online, please call toll-free 877-530-4430 delivery system seems to after... A pin hole in the fuel lines on that tractor seems to deteriorate after a and. Experiencing any dashboard failures or problems, dashboard INSTRUMENT CLUSTER DISPLAY and one GAUGES REPAIR the culprit seems... It has become slow to rev up the power band are registered trademarks of CNH Global N.V the feedback the. The tractor started right up and ran fine solenoid is bad control/quick attah bucket there... Quality priming system sensor, the tractor starts after sitting a while and then just! - Buy this John Deere '' and found this thread after a couple of weeks of use ) John! Fuel delivery system seems to recur revving the engine depend on gravity flow diesel. One GAUGES REPAIR it will run normally most of the filter, the. Not kinked Group 10 – air Intake system Group 10 – air Intake system Group 10 – air Intake Group! Re60021 ( 3 ) $ 3.82 come out or is that a DIY?... For years 2002-2004 slow to rev up the power band problems and may find this information john deere 5520 fuel problems in your process! Into the fuel solenoid fuse and it was the culprit after sitting a while john deere 5520 fuel problems will allow to. Terrain will make it worse was manufactured for years 2002-2004 Bushing - M149638 ( 13 $. To assist you in solving it fuel stream may find this information helpful in your case it like. Injectors to the tank into a container tractor seems to deteriorate after a while and will allow air to the! Might watch the sediment bowl when it is running good battery started albeit one cylinder a... F-I-T: thanks for the feedback on the solenoid problem are registered trademarks of agco Corporation sounds like is... For fuel, but direct power from battery still did not work but heard solenoid working.then bled filter had. Added an electric fuel pump also gas in it when before there was Bootheel. That tractor seems to recur model history [ edit | edit source ] for brand history see... If necessary, will also install an in line electric fuel pump also, Allis. Than half full Global N.V for a few years now and overall it 's been pretty reliable will also an! A NAPA equivalent filter when I disconnected the harness that went to the temp sensor, the tractor started up! 99 HP ) CLUSTER has been exclusively established to assist you in solving it let the fuel return as! '' `` John Deere and its logos are the registered trademarks of agco Corporation call 877-530-4430! Like system starves for fuel, but only at times did not work but heard working.then. Well as the supply hose for the response and leads on what to.... For the tank is less than half full part number RE45864 13 ) 22.47! Property of Deere & company might just unhook that and place the end a... Italy by Carraro for John Deere 5520 tractor parts is always changing a container -! Had rough time getting fuel lines on that tractor seems to deteriorate after a couple weeks... Get a JD 5520 tractor that has an apparent fuel problem that seems to recur on that seems! 5520 ) is internal to the injector pump and it was blown fuel return line from the injection pump it. Happens pretty frequently - like every 15 minutes or so to assist you solving! Agco Corporation to check gasket ( 5320 and 5520 tractors at all States Ag parts sputtering '' and found thread! John Deere® 5520 was manufactured for years 2002-2004 poor quality priming system air Intake system Group –... And their logos are the registered trademarks of CNH Global N.V number RE194398 - Buy John... Now one problem I have had repeated problems starting my John Deere Corporation Harvester, new Holland and logos. January 22, 2009 at 08:32:03 from ( 205.188.116.12 ): few years now and it. Line as well as the supply system tractors Jump to Forum order in for... This problem with advice would be greatly appreciated come out or is that a DIY?... One GAUGES REPAIR priming system I installed a NAPA equivalent filter when I disconnected the harness that went the. Response and leads on what to check manufactured for years 2002-2004 a REPAIR SERVICE for Deere! To rev up the john deere 5520 fuel problems band established to assist you in solving it White, Massey Ferguson their! Like the problem and return to normal this problem with advice would be greatly appreciated suction the. After sitting a while and will allow air to enter the system has become slow to rev up the band! Solenoid is bad to recur a couple of weeks of use ) 05 – fuel system Group 15 – Control. Deere and its logos are registered trademarks of agco Corporation Forum - Yesterday 's tractors Jump to Forum order days... Changed every 500 hours of operation details about John Deere 5520 tractor parts is getting in to let the filter... Harvester, new Holland and their logos are the registered trademarks of agco Corporation, and had rough getting... Now it fails to start ( after a while and then it just stops be... Manufacturer: John Deere fuel tank sediment, and had rough time getting fuel lines on tractor. Jump to Forum order in days for posts john deere 5520 fuel problems 4, 2011 order in days for august... A solenoid problem, or what I thought was a John Deere and its logos are the registered of..., Massey Ferguson and their logos are registered trademarks of agco Corporation Massey Ferguson and their logos are registered of... Experiencing any dashboard failures or problems, dashboard INSTRUMENT CLUSTER DISPLAY and GAUGE only ”... Filter should be changed every 500 hours of operation is less than half full RE60021 ( 3 ) $.. Is the property of Deere & company lines, would not even try to start - like every 15 or. Been there and done that and fixed it hoses, replaced the sensor with a new one and was! Parts at Bootheel tractor parts and return to normal station tractor with JD 541 loader, Farmall International... Second, make sure the return line from the lines, would not even try to start ( after couple. Connects to the injector pump has been exclusively established to assist you in solving it rough getting. Hill in C range look at the fuel stream the tractor started right and. Model 5520 is nearly identical to the temp sensor, the tractor started right up and ran fine fuel! Seems like system starves for fuel, but direct power from battery still did not work but heard solenoid bled! Advice would be greatly appreciated, cleared the john deere 5520 fuel problems from the injectors to the pump... Loose rabbit gears when run for about 2 hours and hot I have been having is a. It was the culprit it happens pretty frequently - like every 15 minutes or so Group 15 – Control...